Recall campaign records

Summary
ON CERTAIN COMPRESSED NATURAL GAS (CNG) VEHICLES, IN THE EVENT OF A SEVERE INTERIOR FIRE IN THE AREA OF THE REAR SEAT, THE CNG TANK MAY BE HEATED UNEVENLY, PREVENTING THE PRESSURE RELIEF DEVICE FROM VENTING THE CONTENTS OF THE TANK AS DESIGNED.

Consequence
THIS COULD RESULT IN A TANK RUPTURE, EXPLOSION, AND EJECTION OF THE TANK FROM THE VEHICLE.

Remedy
DEALERS WILL INSTALL A HEAT INSULATOR MATERIAL TO THE REAR SEAT BACK. AN INTERIM OWNER LETTER WAS MAILED TO OWNERS BEGINNING NOVEMBER 26, 2007. WHEN PARTS ARE AVAILABLE, OWNERS WILL BE RENOTIFIED ASKING THEM TO BRING IN THEIR VEHICLE FOR REPAIR. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
ON CERTAIN COMPRESSED NATURAL GAS (CNG) VEHICLES, IN THE EVENT OF A SEVERE INTERIOR FIRE IN THE AREA OF THE REAR SEAT, THE CNG TANK MAY BE HEATED UNEVENLY, PREVENTING THE PRESSURE RELIEF DEVICE FROM VENTING THE CONTENTS OF THE TANK AS DESIGNED.

Consequence
THIS COULD RESULT IN A TANK RUPTURE, EXPLOSION, AND EJECTION OF THE TANK FROM THE VEHICLE.

Remedy
DEALERS WILL INSTALL A HEAT INSULATOR MATERIAL TO THE REAR SEAT BACK. AN INTERIM OWNER LETTER WAS MAILED TO OWNERS BEGINNING NOVEMBER 26, 2007. WHEN PARTS ARE AVAILABLE, OWNERS WILL BE RENOTIFIED ASKING THEM TO BRING IN THEIR VEHICLE FOR REPAIR. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
IN CERTAIN VEHICLES, TWO SOFTWARE ERRORS HAVE BEEN FOUND IN THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) CONTROL UNIT SOFTWARE. THIS MAY RESULT IN A LATE DEPLOYMENT OF THE INFLATABLE CURTAIN (IC) AND SIDE IMPACT PROTECTION SYSTEM (SIPS) AIR BAGS IN CERTAIN SIDE IMPACT CRASH SITUATIONS. IN ADDITION, THIS SOFTWARE ERROR MAY ALSO CAUSE THE 'SRS AIRBAG - SERVICE URGENT' MESSAGE AND SRS WARNING LIGHT TO ILLUMINATE.

Consequence
LATE DEPLOYMENTOF THE IC AND SIPS AIR BAGS IN CERTAIN SIDE IMPACT CRASH SITUATIONS COULD INCREASE THE RISK OF INJURY TO THE VEHICLE OCCUPANT.

Remedy
DEALERS WILL PERFORM A SOFTWARE UPGRADE OF THE SRS CONTROL UNIT. THE RECALL BEGAN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Summary
CERTAIN TYC HALOGEN TYPE HEADLAMP ASSEMBLIES P/N 20-6644-00 SOLD AS AFTERMARKET EQUIPMENT FOR 2005-2006 NISSAN ALTIMA PASSENGER VEHICLES. THE PHOTOMETRIC WERE MISALIGNED WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence
MISALIGNMENT OF THE LIGHTS DIMINISHES FRONTAL ILLUMINATION WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy
GENERA WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE NONCOMPLIANT LAMPS. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS CAN CONTACT GENERA AT 714-522-6688.

Summary
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE.

Consequence
THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.

Remedy
DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE.

Consequence
THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.

Remedy
DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE. WATER CAN SHORT OUT THE ELECTRONIC CONTROL RELAY FOR THE SLIDE-OUT ROOM CONTROL MECHANISM.

Consequence
THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.

Remedy
DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE. WATER CAN SHORT OUT THE ELECTRONIC CONTROL RELAY FOR THE SLIDE-OUT ROOM CONTROL MECHANISM.

Consequence
THE WIDE VEHICLE WIDTH COULD LEAD TO COLLISIONS WHILE TRAVELING OR SLIDE-OUT ROOM IMPACT TO ADJACENT OBJECTS WHILE THE MOTOR HOME IS PARKED.

Remedy
DEALERS WILL INSPECT AND IF NECESSARY, RELOCATE CERTAIN ELECTRICAL COMPONENTS AND SEAL ASSOCIATED COMPARTMENTS FROM THE ELEMENTS. THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.

Summary
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE REAR AND REAR-SIDE RED REFLECTORS ARE LOCATED ABOVE THE 60-INCH HEIGHT LIMIT.

Consequence
NON-STANDARD SIDE MARKER AND REFLECTOR LIGHTS COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL ADD REFLEX REFLECTORS IN COMPLIANT LOCATIONS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT WINNEBAGO AT 641-585-3535.

Summary
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE REAR AND REAR-SIDE RED REFLECTORS ARE LOCATED ABOVE THE 60-INCH HEIGHT LIMIT.

Consequence
NON-STANDARD SIDE MARKER AND REFLECTOR LIGHTS COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL ADD REFLEX REFLECTORS IN COMPLIANT LOCATIONS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT WINNEBAGO AT 641-585-3535.

Summary
CERTAIN MOTOR HOMES BUILT ON GM CHASSIS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE ANTI-LOCK BRAKE SYSTEM (ABS) MODULE IS PROGRAMMED INCORRECTLY. WHEN THE BRAKES ARE APPLIED, THE STOP LAMPS WILL ILLUMINATE. WHEN THE BRAKE PEDAL IS RELEASED AND THE STOP LAMPS ARE NO LONGER ILLUMINATED BUT THE REAR BRAKES MAY STILL BE APPLIED. THE BRAKE MAY RELEASE AFTER A FEW SECONDS OR AFTER THE NEXT FIRM BRAKE PEDAL APPLICATION.

Consequence
IF THE REAR BRAKES ARE STILL APPLIED AFTER RELEASE OF THE BRAKE PEDAL, THE DRIVER MAY NOTICE A SUBSTANTIAL DRAG WHEN DRIVING AND MAY NEED TO DEPRESS THE GAS PEDAL FURTHER THAN USUAL TO CONTINUE VEHICLE MOVEMENT. A VEHICLE DRIVEN WITH THE BRAKES APPLIED CAN CAUSE OVERHEATING OF THE BRAKES, RESULTING IN INCREASED STOPPING DISTANCE WHICH COULD RESULT IN A CRASH.

Remedy
R-VISON IS WORKING WITH GM WHO WILL REPROGRAM THE ABS MODULE FREE OF CHARGE (PLEASE SEE 07V342). OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9643 OR R-VISION AT 574-268-2111.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.

Consequence
IF THE LATERAL CONTROL ROD BRACKET FRACTURES, THE HANDLING OF THE VEHICLE WILL BE ADVERSELY AFFECTED, INCLUDING POSSIBLE LOSS OF VEHICLE CONTROL.

Remedy
LINK WILL NOTIFY OWNERS AND PROVIDE REPAIR KITS FREE OF CHARGE AND WILL REIMBURSE FOR LABOR AND INSPECTION COSTS. THE RECALL BEGAN JUNE 7, 2007. OWNERS CAN CONTACT LINK TOLL-FREE AT 1-800-222-6283.

Summary
ON CERTAIN MOTOR HOMES, THE SPARE TIRE CARRIER ASSEMBLY MOUNTED UNDER THE REAR OF THE UNIT IS THE INCORRECT MODEL TO PROPERLY SUPPORT THE SPARE TIRE.

Consequence
AS A RESULT, THE POTENTIAL EXISTS FOR THE SPARE TIRE TO BECOME DETACHED FROM THE CARRIER ASSEMBLY AND FALL TO THE ROAD SURFACE. SHOULD THE SPARE TIRE DETACH ITSELF FROM THE CARRIER WHILE THE VEHICLE IS IN MOTION, A CRASH MAY RESULT.

Remedy
DEALERS WILL INSTALL THE CORRECT SPARE TIRE SYSTEM AND ALSO A SECONDARY MECHANICAL BACK-UP LATCH. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.

Summary
ON CERTAIN FOLDING CAMPING TRAILERS (FCT) EQUIPPED WITH A POWER WINCH UNIT, MODEL P55000, BUILT BY CAREFREE OF COLORADO, AN INCORRECT MATERIAL WAS USED IN THE MANUFACTURE OF THE CABLE SHAFTS ON SOME OF THESE POWER WINCH UNITS. UNDER CERTAIN CIRCUMSTANCES WHILE THE FOLDING CAMPING TRAILER TOP IS BEING LIFTED, IF THE WINCH IS PLACED INTO A STALL CONDITION, THE CABLE SHAFT MAY BREAK PRIOR TO THE FUSE OR CIRCUIT BREAKER TRIPPING.

Consequence
SHOULD THE CABLE SHAFT BREAK, THE FCT TOP COULD THEN FREE-FALL INTO THE LOWER POSITION, POSSIBLY RESULTING IN INJURIES.

Remedy
DEALERS WILL INSTALL NEW CABLE SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2007. OWNERS MAY CONTACT STARCRAFT AT 260-593-2550.

Summary
ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.

Consequence
IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE AND CREATE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL TIGHTEN TWO MUFFLER MOUNTING BOLTS TO THE PROPER TORQUE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.

Summary
ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.

Consequence
IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE AND CREATE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL TIGHTEN TWO MUFFLER MOUNTING BOLTS TO THE PROPER TORQUE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.

Summary
ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.

Consequence
IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE AND CREATE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL TIGHTEN TWO MUFFLER MOUNTING BOLTS TO THE PROPER TORQUE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.

Summary
CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE LABEL LOCATED ON THE LOWER ROADSIDE FRONT OF THE UNIT CONTAINS AN IMPROPER LISTING OF THE TIRE AND RIM.

Consequence
THERE MAY BE CONFUSION AS TO THE PROPER REPLACEMENT TIRE IF IT IS NECESSARY.

Remedy
DEALERS WILL MAIL THE CORRECTED FEDERAL COMPLIANCE TAG AND TIRE LOAD INFORMATION TO THE DEALERS OR RETAIL CUSTOMERS. THEY CAN BE PLACED OVER THE INCORRECT LABEL AFTER CLEANING THE SURFACE WITH ALCOHOL. CUSTOMERS WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT FOREST RIVER AT 574-534-3167.

Summary
ON CERTAIN TRAVEL TRAILERS, THE LP SUPPLY HOSE FOR THE OUTSIDE RANGE IS CONNECTED TOO CLOSE TO THE RANGE. IN CERTAIN WINDY CONDITIONS, THE HEAT FROM THE RANGE BURNER MAY CAUSE THE HOSE TO MELT.

Consequence
THIS RESULTS IN AN INCREASED RISK OF FIRE, PERSONAL INJURY AND PROPERTY DAMAGE.

Remedy
DEALERS WILL REPLACE THE COPPER LP TUBING THAT IS CONNECTED TO THE OUTSIDE RANGE WITH ONE OF THE CORRECT LENGTH. THE RECALL BEGAN ON OCTOBER 19, 2007. OWNERS MAY CONTACT KEYSTONE RV AT 1-866-425-4369.

Summary
CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH DRIVER SEATS BUILT BY VILLA INTERNATIONAL FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." THE LOWER SLIDE RAILS OF THE AIR SUSPENSION CAN FAIL.

Consequence
IN THE EVENT OF A VEHICLE CRASH, SEPARATION OF THE SEAT FROM THE SEAT PEDESTAL MAY LEAD TO PERSONAL INJURY OF THE VEHICLE OCCUPANTS.

Remedy
MONACO IS WORKING WITH VILLA TO INSTALL TWO REINFORCEMENT TETHERS BETWEEN THE FRONT OF THE SEAT PEDESTAL AND THE TOP OF THE AIR SUSPENSION FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2007. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTORCYCLES, THE WATER IMPELLER DOES NOT TURN DUE TO THE INSTALLATION OF AN INCORRECT LAYSHAFT. IMPROPER OPERATION OF THE WATER PUMP COULD OCCUR CAUSING OVERHEATING OF THE ENGINE COMPONENTS AND POSSIBLY ENGINE SEIZURE.

Consequence
IF THE ENGINE STOPPED WHILE THE MOTORCYCLE WAS BEING DRIVEN, IT COULD INCREASE THE RISK OF A CRASH.

Remedy
DEALERS WILL CHECK THE WATER PUMP FOR PROPER OPERATION AND WILL REPLACE IT IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 14, 2007. OWNER MAY CONTACT DUCATI AT 408-253-0499.

Summary
ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence
THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy
DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence
THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy
DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence
THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy
DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence
THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy
DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN MOTORCYCLES, THE BATTERY CAN MOVE SIDE TO SIDE INSIDE THE FUEL TANK MOUNTING COMPARTMENT. THIS MOVEMENT COULD RESULT IN MAIN WIRING HARNESS DAMAGE AT THE BATTERY TERMINAL. THIS CONDITION COULD CAUSE AN ELECTRICAL SHORT CONSEQUENTLY STOPPING THE ENGINE.

Consequence
IF THE ENGINE STOPS WHILE THE MOTORCYCLE IS BEING DRIVEN, IT COULD INCREASE THE RISK OF A CRASH.

Remedy
DEALERS WILL INSTALL A BATTERY MOUNTING BRACKET AND TWO DOUBLE LOCK VELCRO STRIPS ON THE BOTTOM OF THE BATTERY. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DUCATI MOTORCYCLES AT 1-408-253-0499.

Summary
ON CERTAIN CAB/CHASSIS PICKUP TRUCKS EQUIPPED WITH AN OPTIONAL 23 GALLON FUEL TANK, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.

Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

Remedy
DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS AND FASTENERS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 12, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, 'POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS.' UNDER THE STANDARD, THE SUNROOF MAY ONLY BE CLOSED WHEN THE IGNITION IS ON, OR AFTER THE IGNITION IS TURNED OFF, BUT BEFORE EITHER OF THE FRONT DOORS ARE OPENED. THE AFFECTED VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNROOF CAN BE CLOSED AFTER THE IGNITION IS TURNED OFF AND THE DOORS ARE OPENED.

Consequence
THIS STANDARD SPECIFIES REQUIREMENTS FOR POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS TO MINIMIZE THE LIKELIHOOD OF DEATH OR INJURY FROM THEIR ACCIDENTAL OPERATION.

Remedy
DEALERS WILL INSTALL A WIRE HARNESS. THE RECALL BEGAN ON MAY 29, 2008. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, 'POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS.' UNDER THE STANDARD, THE SUNROOF MAY ONLY BE CLOSED WHEN THE IGNITION IS ON, OR AFTER THE IGNITION IS TURNED OFF, BUT BEFORE EITHER OF THE FRONT DOORS ARE OPENED. THE AFFECTED VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNROOF CAN BE CLOSED AFTER THE IGNITION IS TURNED OFF AND THE DOORS ARE OPENED.

Consequence
THIS STANDARD SPECIFIES REQUIREMENTS FOR POWER OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS TO MINIMIZE THE LIKELIHOOD OF DEATH OR INJURY FROM THEIR ACCIDENTAL OPERATION.

Remedy
DEALERS WILL INSTALL A WIRE HARNESS. THE RECALL BEGAN ON MAY 29, 2008. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN RECREATIONAL VEHICLES, THE POWER LIFT ROOF SYSTEM, WHICH CONSISTS OF A POWER LIFT MOTOR AND CURRENT LIMITER CONTROLLER, GENERATES EXCESSIVE AMOUNTS OF IMPACT TORQUE IF THE POWER LIFT IS OPERATED WITH THE 30A POWER CORD PLUGGED INTO A 110V AC POWER SOURCE (WITH OR WITHOUT A BATTERY).

Consequence
THIS COULD CAUSE FAILURE IN ONE OF THE SHEAR PINS RESULTING IN DAMAGE TO THE TRAILER'S LIFT SYSTEM. THIS COULD ALLOW THE ROOF TO FREE-FALL FROM THE RAISED POSITION, POSSIBLY RESULTING IN PERSONAL INJURY, VEHICLE AND/OR PROPERTY DAMAGE.

Remedy
OWNERS WILL BE PROVIDED WITH TWO WARNING STICKERS THAT EXPLAINS THE PROPER FUNCTION OF THE POWER LIFT ACCESSORY USING A BATTERY ONLY. ONE STICKER WILL BE PLACED AT THE REAR OF THE TRAILER NEXT TO THE CURRENT LIMITER. THE SECOND STICKER WILL BE PLACED NEXT TO THE 30A POWER CORD OUTLET. IN ADDITION, FLEETWOOD FOLDING TRAILERS WILL SEND A COPY OF THE OPERATION MANUAL THAT EMPHASIZES THE BATTERY-ONLY OPERATION OF THIS TRAILER ACCESSORY. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT FLEETWOOD FOLDING TRAILERS AT 1-814-443-7367.

Summary
ON CERTAIN EMERGENCY VEHICLES EQUIPPED WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING RODS WHICH TRANSFER ENERGY FROM THE PISTON TO THE CRANKSHAFT ARE DEFECTIVE AND CAN RESULT IN SEIZURE OF THE PISTON PIN. A PISTON PIN SEIZURE CAN RESULT IN A MISSION-DISABLING ENGINE FAILURE.

Consequence
THIS CONDITION COULD ULTIMATELY RESULT IN A LOSS OF VEHICLE POWER (ENGINE STALL) INCREASING THE RISK OF A CRASH.

Remedy
PACCAR IS WORKING WITH CUMMINS TO REPLACE THE CONNECTING RODS FREE OF CHARGE (PLEASE SEE 06E037). OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS OR KENWORTH AT 1-425-828-5440.

Summary
ON CERTAIN WALK-IN DELIVERY VANS, THE HEADLIGHT MODULES WERE INCORRECTLY WIRED. THIS CAN CAUSE THE HEADLAMP TO OPERATE WITH REDUCED EFFECTIVENESS.

Consequence
POOR LIGHTING FROM THE HEADLIGHTS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
OWNERS WILL BE PROVIDED WITH DETAILED INSTRUCTIONS FOR THE VERIFICATION AND REPAIR OF THE WIRING DEFECT. OWNERS WILL BE REIMBURSED FOR THE LABOR COST OF THE REPAIRS. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT UTILIMASTER AT 1-800-582-3454.

Summary
ON CERTAIN GRAIN TRAILERS, THE FASTENERS IN THE REAR MOUNTING ANGLES OF THE ALUMINUM KING PIN RUNNER ATTACHMENT TO THE I-BEAM CAN FAIL.

Consequence
IF THE FASTENERS FAIL, THIS COULD COMPROMISE THE STRENGTH OF THE KING PIN ASSEMBLY AND INCREASE THE RISK OF A CRASH.

Remedy
WILSON TRAILER WILL HAVE A LOCAL REPAIR FACILITY INSPECT THE REAR MOUNTING ANGLES FASTENERS, MAKE NECESSARY REPAIRS, AND ADD ADDITIONAL FASTENERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 19, 2007. OWNERS MAY CONTACT WILSON TRAILER AT 1-800-798-2002.

Summary
ON CERTAIN TRAILERS, STAINLESS STEEL MOUNTING BOLTS OF A LESSER GRADE WERE USED IN LIEU OF THE STANDARD GRADE 8 CARBON STEEL BOLTS TO ATTACH THE PINTLE HOOKS.

Consequence
THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE FROM THE SEMI-TRAILER WHICH COULD RESULT IN A CRASH.

Remedy
DEALERS WILL INSTALL THE GRADE 8 CARBON STEEL BOLTS IN ORDER TO INSURE THAT THE MOUNTING OF THE PINTLE HOOK MEETS THE REQUIRED RECOMMENDATIONS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT GREAT DANE AT 1-800-633-4176.

Summary
ON CERTAIN TRAILERS, STAINLESS STEEL MOUNTING BOLTS OF A LESSER GRADE WERE USED IN LIEU OF THE STANDARD GRADE 8 CARBON STEEL BOLTS TO ATTACH THE PINTLE HOOKS.

Consequence
THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE FROM THE SEMI-TRAILER WHICH COULD RESULT IN A CRASH.

Remedy
DEALERS WILL INSTALL THE GRADE 8 CARBON STEEL BOLTS IN ORDER TO INSURE THAT THE MOUNTING OF THE PINTLE HOOK MEETS THE REQUIRED RECOMMENDATIONS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT GREAT DANE AT 1-800-633-4176.

Summary
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT'" CERTAIN FRONT AND REAR SIDE MARKER LIGHTS WERE NOT INSTALLED ON THE AFFECTED UNITS.

Consequence
MISSING SIDE MARKER LIGHTS COULD REDUCE THE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL INSTALL THE MISSING SIDE MARKER LIGHTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2007. OWNERS MAY CONTACT NATIONAL RV AT 1-800-999-7260. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE <A HREF=HTTP://WWW.CACB.USCOURTS.GOV>HTTP://WWW.CACB.USCOURTS.GOV</A> . ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT <A HREF=HTTP://WWW.OMNIMGT.COM/NATIONALRV>HTTP://WWW.OMNIMGT.COM/NATIONALRV</A> . NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.

Summary
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT'" CERTAIN FRONT AND REAR SIDE MARKER LIGHTS WERE NOT INSTALLED ON THE AFFECTED UNITS.

Consequence
MISSING SIDE MARKER LIGHTS COULD REDUCE THE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL INSTALL THE MISSING SIDE MARKER LIGHTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2007. OWNERS MAY CONTACT NATIONAL RV AT 1-800-999-7260. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE <A HREF=HTTP://WWW.CACB.USCOURTS.GOV>HTTP://WWW.CACB.USCOURTS.GOV</A> . ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT <A HREF=HTTP://WWW.OMNIMGT.COM/NATIONALRV>HTTP://WWW.OMNIMGT.COM/NATIONALRV</A> . NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.

Summary
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT'" CERTAIN FRONT AND REAR SIDE MARKER LIGHTS WERE NOT INSTALLED ON THE AFFECTED UNITS.

Consequence
MISSING SIDE MARKER LIGHTS COULD REDUCE THE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL INSTALL THE MISSING SIDE MARKER LIGHTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2007. OWNERS MAY CONTACT NATIONAL RV AT 1-800-999-7260. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), AN AGENCY OF THE UNITED STATES DEPARTMENT OF TRANSPORTATION, HAS BEEN NOTIFIED THAT NATIONAL RV, INC. AND ITS HOLDING COMPANY, NATIONAL RV HOLDINGS, INC., HAVE FILED FOR BANKRUPTCY. NHTSA HAS BEEN ADVISED THAT OWNERS WHO WISH TO PURSUE CLAIMS RELATED TO SAFETY RECALL REPAIR WORK ON THEIR NATIONAL RV VEHICLES MAY FILE A PROOF OF CLAIM WITH THE UNITED STATES BANKRUPTCY COURT FOR THE CENTRAL DISTRICT OF CALIFORNIA, RIVERSIDE DIVISION. THE CASE NUMBER ASSIGNED TO THIS MATTER IS 07-17941. THE PROOF OF CLAIM FORM AND INSTRUCTIONS ARE AVAILABLE ONLINE AT THE COURT'S WEBSITE <A HREF=HTTP://WWW.CACB.USCOURTS.GOV>HTTP://WWW.CACB.USCOURTS.GOV</A> . ADDITIONAL INFORMATION ABOUT THE BANKRUPTCY AND ITS PROCEEDINGS MAY ALSO BE FOUND AT <A HREF=HTTP://WWW.OMNIMGT.COM/NATIONALRV>HTTP://WWW.OMNIMGT.COM/NATIONALRV</A> . NATIONAL RV'S PHONE NUMBER IS (951) 943-6007. INFORMATION ABOUT SAFETY RECALLS ON NATIONAL RV'S PRODUCTS MAY BE FOUND AT WWW.SAFERCAR.GOV. THE NHTSA WISHES TO ADVISE OWNERS OF RECALLED PRODUCTS THAT, IN THE INTERESTS OF THEIR SAFETY AND THE SAFETY OF THE MOTORING PUBLIC, ALL SAFETY RECALL WORK SHOULD BE PERFORMED ON MOTOR VEHICLES AND ITEMS OF EQUIPMENT.

Summary
CERTAIN ALL WEATHER FLOOR MATS (AWFM) SPECIFICALLY SOLD AS AN OPTIONAL ACCESSORY FOR USE ON THE 2007 AND 2008 MODEL YEAR LEXUS ES350 AND TOYOTA CAMRY VEHICLES. THE AWFM INCLUDES TWO GROMMET HOLES AND RETAINING HOOKS (CLIPS) TO SECURE THE MAT TO THE VEHICLE'S CARPET. IF THE AWFM IS NOT SECURED BY ITSELF OR IF IT IS PLACED ON TOP OF AN EXISTING CARPETING FLOOR MAT, THE MAT COULD MOVE FORWARD DURING THE VEHICLE USAGE AND IT MAY INTERFERE WITH THE ACCELERATOR PEDAL.

Consequence
THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION WHEN RETURNING TO THE IDLE POSITION. IF THIS CONDITION OCCURS, IT MAY INCREASE THE POSSIBILITY OF A CRASH.

Remedy
TOYOTA WILL NOTIFY OWNERS OF ALL 2007 AND 2008 LEXUS ES350 AND TOYOTA CAMRY VEHICLES ABOUT THE RECALL EVEN THOUGH NOT ALL OF THESE OWNERS WILL HAVE PURCHASED THE ALL WEATHER MATS. IF THE OWNER HAD NOT PURCHASED THE MATS, THEY ARE NOT AFFECTED BY THE RECALL. THIS LETTER WILL ADVISE OWNERS WHEN REPLACEMENT MATS WILL BE AVAILABLE OR HOW TO RETURN THE ALL WEATHER FLOOR MAT SET TO OBTAIN A REFUND. A SECOND LETTER WILL BE SENT AFTER MATS ARE AVAILABLE REQUESTING OWNERS TO RETURN THEIR MATS TO A LEXUS OR TOYOTA DEALER FOR EXCHANGE OF THE DRIVER'S SIDE MAT. THE FIRST LETTER IS EXPECTED TO BE SENT DURING EARLY OCTOBER 2007 AND THE SECOND IN LATE NOVEMBER 2007. OWNERS CAN CONTACT THE LEXUS CUSTOMER ASSISTANCE CENTER AT 1-800-255-3987 OR THE TOYOTA CUSTOMER EXPERIENCE CENTER AT 1-888-270-9371.

Summary
CERTAIN ALL WEATHER FLOOR MATS (AWFM) SPECIFICALLY SOLD AS AN OPTIONAL ACCESSORY FOR USE ON THE 2007 AND 2008 MODEL YEAR LEXUS ES350 AND TOYOTA CAMRY VEHICLES. THE AWFM INCLUDES TWO GROMMET HOLES AND RETAINING HOOKS (CLIPS) TO SECURE THE MAT TO THE VEHICLE'S CARPET. IF THE AWFM IS NOT SECURED BY ITSELF OR IF IT IS PLACED ON TOP OF AN EXISTING CARPETING FLOOR MAT, THE MAT COULD MOVE FORWARD DURING THE VEHICLE USAGE AND IT MAY INTERFERE WITH THE ACCELERATOR PEDAL.

Consequence
THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION WHEN RETURNING TO THE IDLE POSITION. IF THIS CONDITION OCCURS, IT MAY INCREASE THE POSSIBILITY OF A CRASH.

Remedy
TOYOTA WILL NOTIFY OWNERS OF ALL 2007 AND 2008 LEXUS ES350 AND TOYOTA CAMRY VEHICLES ABOUT THE RECALL EVEN THOUGH NOT ALL OF THESE OWNERS WILL HAVE PURCHASED THE ALL WEATHER MATS. IF THE OWNER HAD NOT PURCHASED THE MATS, THEY ARE NOT AFFECTED BY THE RECALL. THIS LETTER WILL ADVISE OWNERS WHEN REPLACEMENT MATS WILL BE AVAILABLE OR HOW TO RETURN THE ALL WEATHER FLOOR MAT SET TO OBTAIN A REFUND. A SECOND LETTER WILL BE SENT AFTER MATS ARE AVAILABLE REQUESTING OWNERS TO RETURN THEIR MATS TO A LEXUS OR TOYOTA DEALER FOR EXCHANGE OF THE DRIVER'S SIDE MAT. THE FIRST LETTER IS EXPECTED TO BE SENT DURING EARLY OCTOBER 2007 AND THE SECOND IN LATE NOVEMBER 2007. OWNERS CAN CONTACT THE LEXUS CUSTOMER ASSISTANCE CENTER AT 1-800-255-3987 OR THE TOYOTA CUSTOMER EXPERIENCE CENTER AT 1-888-270-9371.

Summary
CERTAIN ALL WEATHER FLOOR MATS (AWFM) SPECIFICALLY SOLD AS AN OPTIONAL ACCESSORY FOR USE ON THE 2007 AND 2008 MODEL YEAR LEXUS ES350 AND TOYOTA CAMRY VEHICLES. THE AWFM INCLUDES TWO GROMMET HOLES AND RETAINING HOOKS (CLIPS) TO SECURE THE MAT TO THE VEHICLE'S CARPET. IF THE AWFM IS NOT SECURED BY ITSELF OR IF IT IS PLACED ON TOP OF AN EXISTING CARPETING FLOOR MAT, THE MAT COULD MOVE FORWARD DURING THE VEHICLE USAGE AND IT MAY INTERFERE WITH THE ACCELERATOR PEDAL.

Consequence
THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION WHEN RETURNING TO THE IDLE POSITION. IF THIS CONDITION OCCURS, IT MAY INCREASE THE POSSIBILITY OF A CRASH.

Remedy
TOYOTA WILL NOTIFY OWNERS OF ALL 2007 AND 2008 LEXUS ES350 AND TOYOTA CAMRY VEHICLES ABOUT THE RECALL EVEN THOUGH NOT ALL OF THESE OWNERS WILL HAVE PURCHASED THE ALL WEATHER MATS. IF THE OWNER HAD NOT PURCHASED THE MATS, THEY ARE NOT AFFECTED BY THE RECALL. THIS LETTER WILL ADVISE OWNERS WHEN REPLACEMENT MATS WILL BE AVAILABLE OR HOW TO RETURN THE ALL WEATHER FLOOR MAT SET TO OBTAIN A REFUND. A SECOND LETTER WILL BE SENT AFTER MATS ARE AVAILABLE REQUESTING OWNERS TO RETURN THEIR MATS TO A LEXUS OR TOYOTA DEALER FOR EXCHANGE OF THE DRIVER'S SIDE MAT. THE FIRST LETTER IS EXPECTED TO BE SENT DURING EARLY OCTOBER 2007 AND THE SECOND IN LATE NOVEMBER 2007. OWNERS CAN CONTACT THE LEXUS CUSTOMER ASSISTANCE CENTER AT 1-800-255-3987 OR THE TOYOTA CUSTOMER EXPERIENCE CENTER AT 1-888-270-9371.

Summary
CERTAIN ALL WEATHER FLOOR MATS (AWFM) SPECIFICALLY SOLD AS AN OPTIONAL ACCESSORY FOR USE ON THE 2007 AND 2008 MODEL YEAR LEXUS ES350 AND TOYOTA CAMRY VEHICLES. THE AWFM INCLUDES TWO GROMMET HOLES AND RETAINING HOOKS (CLIPS) TO SECURE THE MAT TO THE VEHICLE'S CARPET. IF THE AWFM IS NOT SECURED BY ITSELF OR IF IT IS PLACED ON TOP OF AN EXISTING CARPETING FLOOR MAT, THE MAT COULD MOVE FORWARD DURING THE VEHICLE USAGE AND IT MAY INTERFERE WITH THE ACCELERATOR PEDAL.

Consequence
THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION WHEN RETURNING TO THE IDLE POSITION. IF THIS CONDITION OCCURS, IT MAY INCREASE THE POSSIBILITY OF A CRASH.

Remedy
TOYOTA WILL NOTIFY OWNERS OF ALL 2007 AND 2008 LEXUS ES350 AND TOYOTA CAMRY VEHICLES ABOUT THE RECALL EVEN THOUGH NOT ALL OF THESE OWNERS WILL HAVE PURCHASED THE ALL WEATHER MATS. IF THE OWNER HAD NOT PURCHASED THE MATS, THEY ARE NOT AFFECTED BY THE RECALL. THIS LETTER WILL ADVISE OWNERS WHEN REPLACEMENT MATS WILL BE AVAILABLE OR HOW TO RETURN THE ALL WEATHER FLOOR MAT SET TO OBTAIN A REFUND. A SECOND LETTER WILL BE SENT AFTER MATS ARE AVAILABLE REQUESTING OWNERS TO RETURN THEIR MATS TO A LEXUS OR TOYOTA DEALER FOR EXCHANGE OF THE DRIVER'S SIDE MAT. THE FIRST LETTER IS EXPECTED TO BE SENT DURING EARLY OCTOBER 2007 AND THE SECOND IN LATE NOVEMBER 2007. OWNERS CAN CONTACT THE LEXUS CUSTOMER ASSISTANCE CENTER AT 1-800-255-3987 OR THE TOYOTA CUSTOMER EXPERIENCE CENTER AT 1-888-270-9371.

Summary
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence
IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy
DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Summary
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." AND STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THESE VEHICLES MAY HAVE ONE TO FOUR INBOARD SEAT STUD FASTENERS THAT DO NOT MEET SPECIFICATION FOR STRENGTH.

Consequence
IN THE EVENT OF A CRASH, THE SEAT AND SEAT BELT ASSEMBLY MAY NOT RESTRAIN THE OCCUPANT AS INTENDED AND COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy
DEALERS WILL INSPECT THE INBOARD SEAT STUDS AND, IF NECESSARY, REMOVE THE STUD AND INSTALL A BOLT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2007. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876.

Summary
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." AND STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THESE VEHICLES MAY HAVE ONE TO FOUR INBOARD SEAT STUD FASTENERS THAT DO NOT MEET SPECIFICATION FOR STRENGTH.

Consequence
IN THE EVENT OF A CRASH, THE SEAT AND SEAT BELT ASSEMBLY MAY NOT RESTRAIN THE OCCUPANT AS INTENDED AND COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy
DEALERS WILL INSPECT THE INBOARD SEAT STUDS AND, IF NECESSARY, REMOVE THE STUD AND INSTALL A BOLT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2007. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTORCYCLES, WHEN THE ENGINE IS RETURNING TO IDLE IT MAY STALL.

Consequence
IF THE MOTORCYCLE STALLS, THE RIDER WILL HAVE TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT AND DOWNLOAD NEW ENGINE MANAGEMENT SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2007. OWNERS MAY CONTACT TRIUMPH AT 678-854-2010.

Summary
ON CERTAIN MOTOR HOMES BUILT ON PREVOST CHASSIS AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence
THIS COULD CAUSE A DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy
COUNTRY COACH IS WORKING WITH PREVOST AND BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000, PREVOST AT 1-418-831-2046, OR COUNTRY COACH AT 1-800-547-8015.

Summary
ON CERTAIN MOTOR HOMES BUILT ON PREVOST CHASSIS AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence
THIS COULD CAUSE A DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy
COUNTRY COACH IS WORKING WITH PREVOST AND BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000, PREVOST AT 1-418-831-2046, OR COUNTRY COACH AT 1-800-547-8015.

Summary
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE DRIVER'S SIDE THIRD ROW SEAT BELT UPPER ANCHOR BRACKET MAY BE CRACKED.

Consequence
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy
DEALERS WILL REPLACE THE SEAT BELT BRACKET FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 1, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Summary
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE DRIVER'S SIDE THIRD ROW SEAT BELT UPPER ANCHOR BRACKET MAY BE CRACKED.

Consequence
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy
DEALERS WILL REPLACE THE SEAT BELT BRACKET FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 1, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Summary
ON CERTAIN MOTORCYCLES, THE ELECTRONIC CONTROL UNIT (ECU) IGNITION TIMING AND IDLE MIXTURE WERE IMPROPERLY SET DURING PRODUCTION CAUSING THE ENGINE SPEED TO DROP AND STALL THE ENGINE WHEN THE TEMPERATURE OF THE COOLING SYSTEM EXCEEDED 180F.

Consequence
IF THE ENGINE STOPS WHILE THE MOTORCYCLE IS BEING DRIVEN, IT COULD INCREASE THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE ECU MAPPING USING A DEDICATED DIAGNOSTIC SYSTEM INSTRUMENT (DDS) FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT DUCATI AT 201-264-8327.

Summary
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.

Consequence
INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.

Remedy
DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Consequence
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH WITH A 3.2 QD CUMMINS ONAN GENERATOR, THE GENERATOR'S INTERNAL CONTROLLER MAY FAIL; HOWEVER, THE ELECTRICAL CIRCUITS WOULD REMAIN ENERGIZED. INCLUDED IN THESE CIRCUITS IS THE ELECTRONIC PREHEATED ELEMENT WHICH AIDS COLD STARTS AT AMBIENT TEMPERATURES BELOW 0 DEGREES CELSIUS. IN NORMAL OPERATION, THIS CIRCUIT IS ENERGIZED NO LONGER THAN 120 SECONDS AT 30 CELSIUS. IF THE CIRCUIT REMAINS ENERGIZED BEYOND THE DESIGNED PERIOD, THE PREHEATED ELEMENT CAN OVER HEAT.

Consequence
IF THE ELEMENT OVER HEATS, A FIRE IN THE AIR INTAKE SYSTEM COULD OCCUR.

Remedy
WINNEBAGO IS WORKING WITH CUMMINS TO REPLACE THE GENERATORS FREE OF CHARGE (PLEASE SEE 07E076). OWNERS MAY CONTACT CUMMINS AT 812-377-3713 OR WINNEBAGO AT 641-585-3535.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.

Consequence
THE WARNING MAY BE EXPERIENCED BY ERRATIC PERFORMANCE AND EXCESSIVE SMOKE. BOTH OF THESE CONDITIONS MAY RESULT IN A SITUATION WHERE A VEHICLE CRASH COULD OCCUR.

Remedy
COUNTRY COACH IS WORKING WITH CATERPILLAR TO HAVE THE FUEL PUMP REPLACED FREE OF CHARGE (PLEASE SEE 07E053). OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR COUNTRY COACH AT 541-998-3720.

Summary
CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.

Consequence
IMPROPERLY IDENTIFIED EMERGENCY EXITS MAY HINDER EVACUATION EFFORTS.

Remedy
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Summary
CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.

Consequence
IMPROPERLY IDENTIFIED EMERGENCY EXITS MAY HINDER EVACUATION EFFORTS.

Remedy
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Summary
CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.

Consequence
IMPROPERLY IDENTIFIED EMERGENCY EXITS MAY HINDER EVACUATION EFFORTS.

Remedy
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
COUNTRY COACH IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON MAY 3, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR COUNTRY COACH AT 1-800-547-8015.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence
THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy
DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES WITH ALL WHEEL DRIVE, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.

Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

Remedy
DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence
DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Remedy
DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence
DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Remedy
DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence
DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Remedy
DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence
DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Remedy
DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.

Consequence
THIS WOULD INCREASE THE VEHICLE'S STOPPING DISTANCE AND COULD CAUSE A CRASH.

Remedy
DEALERS WILL INSPECT THE FRONT BRAKE CALIPERS TO SEE IF THEY FALL INTO THIS LOT AND, IF SO, WILL REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.

Consequence
THIS WOULD INCREASE THE VEHICLE'S STOPPING DISTANCE AND COULD CAUSE A CRASH.

Remedy
DEALERS WILL INSPECT THE FRONT BRAKE CALIPERS TO SEE IF THEY FALL INTO THIS LOT AND, IF SO, WILL REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.

Consequence
THIS WOULD INCREASE THE VEHICLE'S STOPPING DISTANCE AND COULD CAUSE A CRASH.

Remedy
DEALERS WILL INSPECT THE FRONT BRAKE CALIPERS TO SEE IF THEY FALL INTO THIS LOT AND, IF SO, WILL REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN SPORT UTILITY VEHICLES, FRONT BRAKE CALIPERS IN A CERTAIN LOT MAY HAVE BEEN MANUFACTURED FROM GRAY IRON INSTEAD OF DUCTILE IRON AS DESIGNED AND COULD FRACTURE WITHOUT WARNING.

Consequence
THIS WOULD INCREASE THE VEHICLE'S STOPPING DISTANCE AND COULD CAUSE A CRASH.

Remedy
DEALERS WILL INSPECT THE FRONT BRAKE CALIPERS TO SEE IF THEY FALL INTO THIS LOT AND, IF SO, WILL REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Summary
ON CERTAIN PETERBILT TRUCKS, THE LONGITUDINAL SEAMS ON THE FUEL TANKS WERE FABRICATED USING AN INCORRECT WELD SPEED FOR THE GIVEN MATERIAL THICKNESS. THIS ERROR RESULTED IN A WELD WHICH DID NOT COMPLETELY PENETRATE THE ENTIRE MATERIAL THICKNESS.

Consequence
FUEL TANKS POSSESSING THIS DEFECT COULD LEAK DIESEL FUEL IN THE EVENT OF A CRASH.

Remedy
DEALERS WILL INSPECT AND REPLACE ANY DEFECTIVE FUEL TANKS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 8, 2007. OWNERS MAY CONTACT PETERBILT AT 940-591-4201.

Summary
ON CERTAIN PETERBILT TRUCKS, THE LONGITUDINAL SEAMS ON THE FUEL TANKS WERE FABRICATED USING AN INCORRECT WELD SPEED FOR THE GIVEN MATERIAL THICKNESS. THIS ERROR RESULTED IN A WELD WHICH DID NOT COMPLETELY PENETRATE THE ENTIRE MATERIAL THICKNESS.

Consequence
FUEL TANKS POSSESSING THIS DEFECT COULD LEAK DIESEL FUEL IN THE EVENT OF A CRASH.

Remedy
DEALERS WILL INSPECT AND REPLACE ANY DEFECTIVE FUEL TANKS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 8, 2007. OWNERS MAY CONTACT PETERBILT AT 940-591-4201.

Summary
ON CERTAIN TRUCKS, THE HOOD RESTRAINT CYLINDER DOES NOT CONTAIN ENOUGH DAMPENING TO ADEQUATELY RESTRAIN THE HOOD.

Consequence
THE CYLINDERS COULD POSSIBLY SEPARATE, WHICH WOULD LEAVE THE HOOD UNRESTRAINED WHEN OPENING AND CLOSING THE HOOD.

Remedy
DEALERS WILL REPLACE THE HOOD RESTRAINT CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, THE HOOD RESTRAINT CYLINDER DOES NOT CONTAIN ENOUGH DAMPENING TO ADEQUATELY RESTRAIN THE HOOD.

Consequence
THE CYLINDERS COULD POSSIBLY SEPARATE, WHICH WOULD LEAVE THE HOOD UNRESTRAINED WHEN OPENING AND CLOSING THE HOOD.

Remedy
DEALERS WILL REPLACE THE HOOD RESTRAINT CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, THE HOOD RESTRAINT CYLINDER DOES NOT CONTAIN ENOUGH DAMPENING TO ADEQUATELY RESTRAIN THE HOOD.

Consequence
THE CYLINDERS COULD POSSIBLY SEPARATE, WHICH WOULD LEAVE THE HOOD UNRESTRAINED WHEN OPENING AND CLOSING THE HOOD.

Remedy
DEALERS WILL REPLACE THE HOOD RESTRAINT CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES MANUFACTURED FROM JUNE 6 THROUGH SEPTEMBER 4, 2007. THE OIL FILL CAP MAY SEPARATE FROM THE OIL FILL TUBE ALLOWING ENGINE OIL TO BE EMITTED FROM THE TUBE. OIL COULD WET THE LEFT FRONT BRAKE SHOES/PADS RESULTING IN REDUCED BRAKING CAPACITY.

Consequence
A VEHICLE CRASH COULD OCCUR.

Remedy
BLUE BIRD IS ADVISING THE OWNERS TO REMOVE THEIR BUSES FROM SERVICE UNTIL THEY HAVE THE BUSES REPAIRED AND TO CONTACT A CATERPILLAR DEALER FOR AN INTERIM REPAIR. THE INTERIM REPAIR CONSISTS OF INSTALLING TWO SCREWS THROUGH THE OIL FILL TUBE TO RETAIN THE OIL FILL CAP IN PLACE. CATERPILLAR WILL ISSUE A SEPARATE RECALL NOTIFICATION LETTER TO OWNERS ON OR ABOUT SEPTEMBER 17, 2007 THAT WILL INSTRUCT OWNERS TO CONTACT A CATERPILLAR DEALER TO SCHEDULE AN APPOINTMENT TO HAVE A NEW OIL FILL TUBE INSTALLED AS A PERMANENT REMEDY. THE RECALL BEGAN ON SEPTEMBER 7, 2007. OWNERS CAN CONTACT BLUE BIRD AT 478-822-2242 OR CATERPILLAR AT 800-447-4986.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH SUBURBAN GLASS TOP, SEALED BURNER RANGE OR SLIDE IN COOK TOP, A THREADED CONNECTOR ON THE TUBE BETWEEN THE BURNER VALVE AND THE BURNER MAY NOT HAVE BEEN FULLY TIGHTENED DURING THE MANUFACTURING PROCESS.

Consequence
IF THE THREADED CONNECTOR IS NOT PROPERLY TIGHTENED, IT IS POSSIBLE FOR THE GAS TO LEAK FROM THE CONNECTION WHEN THE BURNER IS TURNED ON. LP GAS IS HEAVIER THAN AIR AND ANY LEAKED GAS COULD ACCUMULATE IN AN ENCLOSED OR LOW AREA IN THE MOTOR HOME. A SUFFICIENT QUANTITY OF ACCUMULATED GAS, IF IGNITED, COULD CAUSE A FIRE OR EXPLOSION.

Remedy
TRAVEL SUPREME IS WORKING WITH SUBURBAN TO HAVE THE BURNER TUBES REPLACED (PLEASE SEE 07E-050) . THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT SUBURBAN AT 423-775-2131 OR TRAVEL SUPREME AT 574-862-1960.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy
MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Summary
ON CERTAIN FEDERAL EXPRESS (FED-EX) TRUCKS EQUIPPED WITH HALDEX ANTILOCK BRAKE SYSTEM (ABS) ELECTRONIC CONTROL UNIT (ECU) VALVES, THE VALVES NEED TO BE MODIFIED IN ORDER TO RELOCATE THE VALVES IN AN UPRIGHT POSITION. THE VALVES CONTAIN A BALL SEAT PISTON THAT MAY BECOME DISLODGED DURING AN ABS EVENT AND NOT PERFORM PROPERLY.

Consequence
DRIVERS WOULD NOT BE WARNED OF A BRAKE SYSTEM FAILURE INCREASING THE RISK OF A CRASH.

Remedy
GREAT DANE IS WORKING WITH FED-EX TO REPLACE THE ABS VALVES FREE OF CHARGE. FED-EX HAS DEAD-LINED THESE VEHICLES UNTIL THE REPAIR HAS BEEN PERFORMED.

Summary
ON CERTAIN VEHICLES, THE WHEEL SPEED SENSOR HOUSING USES AN O-RING SEAL TO PREVENT LEAKAGE TO OR FROM THE WHEEL BEARING. IF ASSEMBLED IMPROPERLY, THE O-RING MAY NOT SEAL PROPERLY ALLOWING WATER TO ENTER THE WHEEL BEARING AND EVENTUALLY CAUSE DAMAGE TO THE BEARING, ESPECIALLY IN AREAS WHERE USE OF ROAD SALT IS PREVALENT. IF THE DRIVER CONTINUES TO DRIVE WITH THIS CONDITION IT IS POSSIBLE FOR THE WHEEL BEARING TO BECOME LOOSE, WHICH COULD CAUSE THE BEARING TO FAIL.

Consequence
THIS COULD CAUSE A WHEEL TO FALL OFF OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.

Remedy
DEALERS WILL INSPECT THE REAR ABS SENSORS AND WHEEL BEARINGS FOR DAMAGED PARTS AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 25, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
ON CERTAIN VEHICLES, THE WHEEL SPEED SENSOR HOUSING USES AN O-RING SEAL TO PREVENT LEAKAGE TO OR FROM THE WHEEL BEARING. IF ASSEMBLED IMPROPERLY, THE O-RING MAY NOT SEAL PROPERLY ALLOWING WATER TO ENTER THE WHEEL BEARING AND EVENTUALLY CAUSE DAMAGE TO THE BEARING, ESPECIALLY IN AREAS WHERE USE OF ROAD SALT IS PREVALENT. IF THE DRIVER CONTINUES TO DRIVE WITH THIS CONDITION IT IS POSSIBLE FOR THE WHEEL BEARING TO BECOME LOOSE, WHICH COULD CAUSE THE BEARING TO FAIL.

Consequence
THIS COULD CAUSE A WHEEL TO FALL OFF OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.

Remedy
DEALERS WILL INSPECT THE REAR ABS SENSORS AND WHEEL BEARINGS FOR DAMAGED PARTS AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 25, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

Consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.

Remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH ASET AC MODEL ENGINES, THE ENGINE AS CONFIGURED WITH AN EXTERNAL EXHAUST GAS RECIRCULATION SYSTEM MAKES SERVICING THE FUEL INJECTION LINES DIFFICULT WHEN USING TRADITIONAL TOOLS. THEREFORE, IT IS POSSIBLE FOR FUEL LEAKS TO DEVELOP WHEN REMOVING AND INSTALLING THE FUEL INJECTION LINES.

Consequence
A LEAK IN THE FUEL INJECTION LINE MAY SPRAY FUEL ON THE HOT SURFACES OF THE EXHAUST GAS RECIRCULATION SYSTEM, WHICH COULD RESULT IN AN ENGINE FIRE.

Remedy
DEALERS WILL REPLACE THE FUEL INJECTION LINES FREE OF CHARGE. NOTE: THIS RECALL SUPERSEDES A PREVIOUS CAMPAIGN CONDUCTED IN 2006 (PLEASE SEE 06V392). THE RECALL BEGAN ON SEPTEMBER 11, 2007, WITH SUBSEQUENT MAILINGS EVERY SIX WEEKS UNTIL APRIL 2008. OWNERS MAY CONTACT MACK AT 800-528-6586.

Summary
ON CERTAIN SEDAN AND HYBRID (CNG) VEHICLES, DURING ASSEMBLY, THE TELESCOPIC STEERING COLUMN MECHANISM MAY HAVE BEEN OVER-LUBRICATED WITH SILICONE GREASE. OVER TIME, SOME OF THIS EXTRA GREASE MAY DRIP ON THE BRAKE LIGHT SWITCH CAUSING THE SWITCH TO FAIL.

Consequence
FAILURE MAY RESULT IN A LOSS OF BRAKE LIGHTS AND AN INCREASED RISK THAT THE VEHICLE COULD BE STRUCK IN THE REAR. IN ADDITION, A FAILED BRAKE LIGHT SWITCH COULD PREVENT SHIFTING THE TRANSMISSION FROM THE PARK POSITION (VEHICLES WITH AN AUTOMATIC TRANSMISSION).

Remedy
DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH AND INSTALL A PROTECTIVE COVER OVERTHE SWITCH FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
ON CERTAIN SEDAN AND HYBRID (CNG) VEHICLES, DURING ASSEMBLY, THE TELESCOPIC STEERING COLUMN MECHANISM MAY HAVE BEEN OVER-LUBRICATED WITH SILICONE GREASE. OVER TIME, SOME OF THIS EXTRA GREASE MAY DRIP ON THE BRAKE LIGHT SWITCH CAUSING THE SWITCH TO FAIL.

Consequence
FAILURE MAY RESULT IN A LOSS OF BRAKE LIGHTS AND AN INCREASED RISK THAT THE VEHICLE COULD BE STRUCK IN THE REAR. IN ADDITION, A FAILED BRAKE LIGHT SWITCH COULD PREVENT SHIFTING THE TRANSMISSION FROM THE PARK POSITION (VEHICLES WITH AN AUTOMATIC TRANSMISSION).

Remedy
DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH AND INSTALL A PROTECTIVE COVER OVERTHE SWITCH FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2007. OWNERS MAY CONTACT HONDA AT 1-800-999-1009.

Summary
ON CERTAIN TRAILERS EQUIPPED WITH COVERED HAYRACKS, THE FASTENERS SECURING THE HAYRACK TO THE ROOF MOUNTING BRACKET MAY FAIL, ALLOWING THE HAYRACK TO SEPARATE FROM THE TRAILER.

Consequence
THIS COULD POSE A SERIOUS HAZARD TO FOLLOWING VEHICLES INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSTALL NEW FASTENERS SECURING THE HAYRACK TO THE MOUNTING BRACKET ON THE ROOF OF THE TRAILER. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT 4-STAR AT 1-800-848-3095.

Summary
ON CERTAIN TRAILERS EQUIPPED WITH COVERED HAYRACKS, THE FASTENERS SECURING THE HAYRACK TO THE ROOF MOUNTING BRACKET MAY FAIL, ALLOWING THE HAYRACK TO SEPARATE FROM THE TRAILER.

Consequence
THIS COULD POSE A SERIOUS HAZARD TO FOLLOWING VEHICLES INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL INSTALL NEW FASTENERS SECURING THE HAYRACK TO THE MOUNTING BRACKET ON THE ROOF OF THE TRAILER. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT 4-STAR AT 1-800-848-3095.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence
THIS COULD DELAY OR FAIL TO APPLY THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy
BENDIX IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE (07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 17, 2007. OWNERS MAY CONTACT BENDIX AT 440-329-9000 OR NEWELL COACH AT 1-888-963-9355.

Summary
ON CERTAIN MOTOR HOMES EQUIPPED WITH BENDIX PARKER CHECK VALVES, THE PARKER BRASS CHECK VALVE WHICH CONNECTS TO THE SUPPLY PORT OF THE BENDIX SR-7 SPRING BRAKE CAN FAIL.

Consequence
THIS CONDITION CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON. THESE CONDITIONS CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY, BRAKE DRAG, OR IN THE CASE OF LOSS OF PRIMARY CIRCUIT, INABILITY TO MODULATE THE SPRING BRAKES.

Remedy
DEALERS WILL REPLACE THE BRASS CHECK VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 9, 2007. OWNERS MAY CONTACT NEWELL COACH AT 1-888-963-9355 OR BENDIX AT1- 440-329-9000.

Summary
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy
WINNEBAGO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR WINNEBAGO AT 641-585-3535.

Summary
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy
WINNEBAGO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR WINNEBAGO AT 641-585-3535.

Summary
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy
WINNEBAGO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR WINNEBAGO AT 641-585-3535.

Summary
ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ENGINES CONFIGURED WITH DIESEL PARTICULATE FILTERS (DPF) AND ULTRA COMPACT MODULES (UCM), THE UCM MAY FAIL. THE UCM IS LOCATED IN A WIRING HARNESS INSIDE THE ENGINE COMPARTMENT ON THE CURB SIDE.

Consequence
THE ENGINE MAY STALL AND THE UCM MAY FAIL CAUSING A FIRE.

Remedy
OWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND PARTS TO REPLACE THE 5 AMP CIRCUIT BREAKER WITH A 2 AMP FUSE TO MITIGATE THE FAILURE OF THE UCM FROM SUBSEQUENTLY CAUSING A FIRE. THE RECALL BEGAN ON JANUARY 25, 2008. OWNERS MAY CONTACT DCBUSNA/ORION BUS AT 905-403-7832.

Summary
ON CERTAIN MOTORCYCLES BUILT WITH A SIDECAR AND EQUIPPED WITH HERZOG TRANSMISSION GEAR SETS, THE TRANSMISSION MAIN SHAFT IS OUTSIDE OF ACCEPTABLE TOLERANCE DUE TO INCORRECT MANUFACTURING OF TRANSMISSION MAIN SHAFT AND SPECIFIC RETAINING CLIPS. THE MAIN SHAFT AND RETAINING CLIPS MAY BE DEFECTIVE.

Consequence
TRANSMISSION DAMAGE, EXCESSIVE GEAR WEAR, HARD SHIFTING, AND POSSIBLE FAILURE CAN OCCUR RESULTING IN REAR WHEEL LOCK UP INCREASING THE RISK OF A CRASH.

Remedy
THE MOTORCYCLES WILL BE INSPECTED AND IF THE TRANSMISSION HAS DEFECTIVE SHAFTS AND RETAINING CLIPS, THE COMPLETE TRANSMISSION WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2007. OWNERS MAY CONTACT IRBIT AT 1-888-990-8484.

Summary
ON CERTAIN MOTOR HOMES, THE PASSENGER SIDE WINDSHIELD WIPER MAY FAIL TO OPERATE PROPERLY.

Consequence
INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE IMPAIRED VISIBILITY WHICH HAS THE POTENTIAL TO RESULT IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy
DEALERS WILL INSTALL NEW WIPER LINKAGE FROM THE WIPER MOTOR TO THE PIVOT ASSEMBLIES. THE RECALL BEGAN ON AUGUST 31, 2007. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-3535.

Summary
CERTAIN BIG DOG AFTERMARKET SISSY BAR ASSEMBLIES SOLD AS AN ACCESSORY PART FOR THE MOTORCYCLES LISTED ABOVE. THE SISSY BAR ASSEMBLIES MAY BE UNDERSIZED, ALLOWING EXCESSIVE MOVEMENT OF THE SISSY BAR. OVER TIME, THIS COULD CAUSE THE BOLTS THAT RETAIN THE SISSY BAR TO BREAK ALLOWING THE SISSY BAR TO DETACH FROM THE MOTORCYCLE.

Consequence
THIS CONDITION COULD OCCUR WITHOUT WARNING AND COULD RESULT IN INJURY AND/OR A CRASH.

Remedy
BIG DOG WILL NOTIFY OWNERS AND REPLACE THE AFFECTED SISSY BARS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 24, 2007. OWNERS CAN CONTACT BIG DOG MOTORCYCLES CUSTOMER SERVICE DEPARTMENT COLLECT AT 316-267-9121.

Summary
CERTAIN BIG DOG AFTERMARKET SISSY BAR ASSEMBLIES SOLD AS AN ACCESSORY PART FOR THE MOTORCYCLES LISTED ABOVE. THE SISSY BAR ASSEMBLIES MAY BE UNDERSIZED, ALLOWING EXCESSIVE MOVEMENT OF THE SISSY BAR. OVER TIME, THIS COULD CAUSE THE BOLTS THAT RETAIN THE SISSY BAR TO BREAK ALLOWING THE SISSY BAR TO DETACH FROM THE MOTORCYCLE.

Consequence
THIS CONDITION COULD OCCUR WITHOUT WARNING AND COULD RESULT IN INJURY AND/OR A CRASH.

Remedy
BIG DOG WILL NOTIFY OWNERS AND REPLACE THE AFFECTED SISSY BARS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 24, 2007. OWNERS CAN CONTACT BIG DOG MOTORCYCLES CUSTOMER SERVICE DEPARTMENT COLLECT AT 316-267-9121.

Summary
CERTAIN BIG DOG AFTERMARKET SISSY BAR ASSEMBLIES SOLD AS AN ACCESSORY PART FOR THE MOTORCYCLES LISTED ABOVE. THE SISSY BAR ASSEMBLIES MAY BE UNDERSIZED, ALLOWING EXCESSIVE MOVEMENT OF THE SISSY BAR. OVER TIME, THIS COULD CAUSE THE BOLTS THAT RETAIN THE SISSY BAR TO BREAK ALLOWING THE SISSY BAR TO DETACH FROM THE MOTORCYCLE.

Consequence
THIS CONDITION COULD OCCUR WITHOUT WARNING AND COULD RESULT IN INJURY AND/OR A CRASH.

Remedy
BIG DOG WILL NOTIFY OWNERS AND REPLACE THE AFFECTED SISSY BARS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 24, 2007. OWNERS CAN CONTACT BIG DOG MOTORCYCLES CUSTOMER SERVICE DEPARTMENT COLLECT AT 316-267-9121.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy
MACK IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 10, 2008. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR MACK AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS EQUIPPED WITH PARKER SINGLE CHECK VALVES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

Consequence
THIS CONDITION CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON. THESE CONDITIONS CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY, BRAKE DRAG, OR IN THE CASE OF LOSS OF PRIMARY CIRCUIT, INABILITY TO MODULATE THE SPRING BRAKES.

Remedy
MACK IS WORKING WITH BENDIX TO REPLACE THE PARKER SINGLE CHECK VALVE. THE RECALL BEGAN ON JANUARY 9, 2008. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR MACK AT 1-800-528-6586.

Summary
ON CERTAIN MOTORCYCLES, EACH TIME THE IGNITION SWITCH IS TURNED OFF, THE ENGINE CONTROL MODULE (ECM) PRE-SETS THE POSITION OF THE IDLE SPEED CONTROL (ISC) VALVE FOR SUBSEQUENT ENGINE STARTING BY OPENING THE VALVE COMPLETELY AND THEN CLOSING IT TO A START-UP POSITION.

Consequence
DUE TO IMPROPER SHAPE OF THE INTERNAL MECHANISM THAT MOVES THE ISC VALVE, THE VALVE MAY REMAIN IN THE OPEN POSITION INSTEAD OF MOVING TO THE CORRECT START-UP POSITION. THIS CAN RESULT IN NO-LOAD ENGINE IDLE SPEEDS AS HIGH AS 5000 RPM THE NEXT TIME THE ENGINE IS STARTED. IF THE RIDER CHOOSES TO OPERATE THE MOTORCYCLE IN THIS CONDITION, THE RIDER MAY HAVE DIFFICULTY OPERATING THE MOTORCYCLE, WHICH COULD RESULT IN A CRASH.

Remedy
DEALERS WILL REPLACE THE ISC VALVE WITH AN IMPROVED PART, AND WILL ALSO REPLACE THE ECM. THE RECALL BEGAN ON AUGUST 22, 2007. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence
EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy
THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Summary
ON CERTAIN 39R MOTOR HOMES, THE PROPANE HOSE, UNDER THE GALLEY SLIDE-OUT ROOM, CAN FLEX AND MAKE CONTACT WITH OTHER COMPONENTS DURING THE SLIDE-OUT ROOM OPERATION.

Consequence
THIS MAY LEAD TO ABRASION OR KINKING OF THE PROPANE HOSE WHICH MAY RESULT IN A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.

Remedy
FLEETWOOD WILL REPLACE THE PROPANE GAS HOSE IF IT IS KINKED OR DAMAGED. IF THE HOSE IS NOT KINKED OR DAMAGED, FLEETWOOD WILL INSTALL INSULATED LOOP CLAMPS TO SECURE THE PROPANE HOSE AWAY FROM COMPONENTS. FLEETWOOD BEGAN CALLING CUSTOMERS ON AUGUST 3, 2007. A CUSTOMER NOTIFICATION MAILING BEGAN ON SEPTEMBER 6, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN 39R MOTOR HOMES, THE PROPANE HOSE, UNDER THE GALLEY SLIDE-OUT ROOM, CAN FLEX AND MAKE CONTACT WITH OTHER COMPONENTS DURING THE SLIDE-OUT ROOM OPERATION.

Consequence
THIS MAY LEAD TO ABRASION OR KINKING OF THE PROPANE HOSE WHICH MAY RESULT IN A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.

Remedy
FLEETWOOD WILL REPLACE THE PROPANE GAS HOSE IF IT IS KINKED OR DAMAGED. IF THE HOSE IS NOT KINKED OR DAMAGED, FLEETWOOD WILL INSTALL INSULATED LOOP CLAMPS TO SECURE THE PROPANE HOSE AWAY FROM COMPONENTS. FLEETWOOD BEGAN CALLING CUSTOMERS ON AUGUST 3, 2007. A CUSTOMER NOTIFICATION MAILING BEGAN ON SEPTEMBER 6, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.

Summary
ON CERTAIN MOTORCYCLES, THE CLAMPING BLOCKS AND THE TOP FORK BRIDGE WERE NOT MANUFACTURED ACCORDING TO SPECIFICATIONS. CONSEQUENTLY, THE HANDLEBARS MIGHT NOT BE HELD SECURELY IN POSITION.

Consequence
IT IS POSSIBLE FOR THE HANDLEBARS TO MOVE OUT OF THEIR CORRECT POSITION WHEN THE MOTORCYCLE IS BEING MANEUVERED, OR WHEN IT IS BEING RIDDEN, INCREASING THE RISK OF A CRASH.

Remedy
DEALERS WILL REPLACE THE TOP FORK BRIDGE AND BOTH CLAMPING BLOCKS ON THESE MOTORCYCLES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Summary
ON CERTAIN TRUCKS BUILT WITH A TRW GLOBAL ADJUSTABLE UPPER STEERING COLUMN, TWO UPPER TILT PLATE BOLTS MAY LOOSEN WITH USE AND FALL OUT. THESE FASTENERS HOLD THE UPPER COLUMN ASSEMBLY IN PLACE. THE STEERING COLUMN PIVOT MAY FRACTURE IF THE BOLTS ARE MISSING WHEN AN EXCESSIVE FORCE IS APPLIED TO THE STEERING WHEEL.

Consequence
LOSS OF STEERING WHEEL POSITION MAY CAUSE THE STEERING TO RESPOND DIFFERENTLY THAN EXPECTED. IF THIS CONDITION IS IGNORED, A CRASH MAY OCCUR.

Remedy
THE TILT PLATE BOLTS WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 23, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS BUILT WITH A TRW GLOBAL ADJUSTABLE UPPER STEERING COLUMN, TWO UPPER TILT PLATE BOLTS MAY LOOSEN WITH USE AND FALL OUT. THESE FASTENERS HOLD THE UPPER COLUMN ASSEMBLY IN PLACE. THE STEERING COLUMN PIVOT MAY FRACTURE IF THE BOLTS ARE MISSING WHEN AN EXCESSIVE FORCE IS APPLIED TO THE STEERING WHEEL.

Consequence
LOSS OF STEERING WHEEL POSITION MAY CAUSE THE STEERING TO RESPOND DIFFERENTLY THAN EXPECTED. IF THIS CONDITION IS IGNORED, A CRASH MAY OCCUR.

Remedy
THE TILT PLATE BOLTS WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 23, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF PART 567, 'CERTIFICATION.' INCORRECT CERTIFICATION LABELS WERE APPLIED TO THESE VEHICLES.

Consequence
SOME CERTIFICATION LABELS MAY NOT CONTAIN THE REQUIRED TIRE AND RIM SIZE INFORMATION.

Remedy
DEALERS WILL REMOVE THE INCORRECT LABEL AND ADHERE THE CORRECT LABEL. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 20, 2007. OWNERS MAY CONTACT ACURA AT 1-800-382-2238.

Summary
CERTAIN MOTOR HOME CHASSIS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Consequence
THE OPERATOR MAY NOTICE HIGHER REQUIRED STEERING WHEEL INPUTS, OR THE NEED FOR MORE STEERING WHEEL ADJUSTMENTS WHILE DRIVING IN A STRAIGHT LINE IN COMBINATION WITH METALLIC CRACKING NOISES PRIOR TO A LOSS OF STEERING. LOSS OF STEERING COULD RESULT IN A VEHICLE CRASH.

Remedy
DEALERS WILL REPLACE THE STEERING GEAR FREE OF CHARGE. PHASE ONE OF THE RECALL BEGAN ON JANUARY 30, 2008 FOR 1,392 VEHICLES. EXPANDED MAILINGS ARE EXPECTED TO BEGIN ON MAY 16, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN MOTOR HOMES BUILT ON SPARTAN MM CHASSIS WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A VEHICLE CRASH.

Remedy
NEWMAR IS WORKING WITH SPARTAN AND CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 , SPARTAN AT 517-543-6400, OR NEWMAR AT 1-574-773-7791.

Summary
ON CERTAIN MOTOR HOMES BUILT ON SPARTAN MM CHASSIS WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A VEHICLE CRASH.

Remedy
NEWMAR IS WORKING WITH SPARTAN AND CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 , SPARTAN AT 517-543-6400, OR NEWMAR AT 1-574-773-7791.

Summary
ON CERTAIN MOTOR HOMES BUILT ON SPARTAN MM CHASSIS WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A VEHICLE CRASH.

Remedy
NEWMAR IS WORKING WITH SPARTAN AND CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 , SPARTAN AT 517-543-6400, OR NEWMAR AT 1-574-773-7791.

Summary
ON CERTAIN MOTORCYCLES, A WARPED BUS BAR WITHIN THE VOLTAGE REGULATOR CAN CAUSE A SHORT CIRCUIT.

Consequence
THIS COULD POSSIBLY RESULT IN A FIRE.

Remedy
DEALERS WILL REPLACE THE EXISTING CIRCUIT BREAKER LOCATED BETWEEN THE VOLTAGE REGULATOR POSITIVE BATTERY LEAD (B+ LEAD) AND THE POSITIVE BATTERY TERMINAL WITH AN ALTERNATIVE CIRCUIT PROTECTION DEVICE THAT WILL PREVENT A THERMAL EVENT IF THERE IS A SHORT TO GROUND. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BIG DOG AT 1-316-219-9129 OR EMAIL TO CUSTOMER.SERVICE@BIGDOGMOTORCYCLES.COM.

Summary
CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES." THE TIRE INFLATION PRESSURE LABEL ON THE ROADSIDE FRONT OF THE VEHICLE HAS INCORRECT AIR PRESSURE INFORMATION. IN ADDITION, THE TIRE, RIM AND TIRE PRESSURE INFORMATION IN THE OWNERS MANUAL IS INCORRECT.

Consequence
AN OVER-INFLATED TIRE COULD BLOW OUT, CAUSING THE TRAILER TO SWAY UNCONTROLLABLY INCREASING THE RISK OF A CRASH.

Remedy
AIRSTREAM WILL MAIL TO THE OWNERS A CORRECTED TIRE INFLATION PRESSURE LABEL AND A LABEL WITH CORRECT TIRE INFORMATION TO BE PLACED IN THE OWNER'S MANUAL OVER THE INCORRECT INFORMATION ALONG WITH INSTALLATION INSTRUCTIONS. IF AN OWNER IS UNCOMFORTABLE INSTALLING EITHER LABEL, THEY CAN TAKE THEIR TRAILER TO A DEALER TO HAVE THE LABELS INSTALLED. THE RECALL BEGAN ON AUGUST 9, 2007. OWNERS CAN CALL AIRSTREAM AT 1-519-262-2600.

Summary
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE UNRESTRAINED SMALL ADULT, THE SYSTEM IS REQUIRED TO TURN THE RIGHT FRONT PASSENGER'S FRONTAL AIRBAG ON. AN ERROR IN THE SEAT SENSOR CALIBRATION CAN CAUSE IT TO FAIL THIS TEST. IN ADDITION, THIS CONDITION CAN PREVENT THE AIRBAG FROM TURNING OFF WHEN THE SEAT IS OCCUPIED BY A SMALL CHILD.

Consequence
WHENEVER THE FRONT PASSENGER SEAT IS OCCUPIED, THE DRIVER SHOULD ALWAYS CHECK THE AIRBAG INDICATOR TO SEE IF THE AIRBAG IS ON OR OFF. IF IT IS NOT CORRECT FOR THE SITUATION, THE PASSENGER SHOULD BE MOVED TO A DIFFERENT SEAT. THIS CAN INCREASE THE RISK OF INJURY TO A SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.

Remedy
DEALERS WILL REPROGRAM THE SEAT'S ELECTRONIC CONTROL UNIT. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Summary
CERTAIN BLUE BIRD MY 2008 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN JUNE 6 AND JULY 27, 2007. A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND CAUSE LOSS OF THROTTLE CONTROL AND EXCESSIVE SMOKE.

Consequence
EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy
BLUE BIRD IS WORKING IN CONJUNCTION WITH CATERPILLAR TO NOTIFY OWNERS TO CONTACT THEIR LOCAL CATERPILLAR DEALER FOR A FREE REMEDY. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2007. OWNERS CAN CONTACT CATERPILLAR AT 1-800-447-4986 OR BLUE BIRD AT 478-822-2242.

Summary
CERTAIN BLUE BIRD MY 2008 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN JUNE 6 AND JULY 27, 2007. A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND CAUSE LOSS OF THROTTLE CONTROL AND EXCESSIVE SMOKE.

Consequence
EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy
BLUE BIRD IS WORKING IN CONJUNCTION WITH CATERPILLAR TO NOTIFY OWNERS TO CONTACT THEIR LOCAL CATERPILLAR DEALER FOR A FREE REMEDY. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2007. OWNERS CAN CONTACT CATERPILLAR AT 1-800-447-4986 OR BLUE BIRD AT 478-822-2242.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence
THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy
DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Summary
ON CERTAIN TRUCKS BUILT WITH AXILOK REAR WHEEL SPINDLE NUTS, THE NUTS MAY HAVE BEEN IMPROPERLY INSTALLED, WITH ONE OR BOTH LOCKING CLIP TABS NOT PROPERLY ENGAGED OR DAMAGED.

Consequence
THIS MAY REDUCE THE NUT'S ABILITY TO RESIST ROTATION, POTENTIALLY ALLOWING THE NUT TO BACK OFF AND THE DUAL WHEEL SET TO SEPARATE FROM THE VEHICLE, RESULTING IN A CRASH WITHOUT PRIOR WARNING.

Remedy
DEALERS WILL INSPECT THE AXILOK NUTS FOR LOCKING CLIP ENGAGEMENT OR DAMAGE. THEY WILL BE ADJUSTED OR REPLACED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 800-547-0712.

Summary
ON CERTAIN TRUCKS BUILT WITH AXILOK REAR WHEEL SPINDLE NUTS, THE NUTS MAY HAVE BEEN IMPROPERLY INSTALLED, WITH ONE OR BOTH LOCKING CLIP TABS NOT PROPERLY ENGAGED OR DAMAGED.

Consequence
THIS MAY REDUCE THE NUT'S ABILITY TO RESIST ROTATION, POTENTIALLY ALLOWING THE NUT TO BACK OFF AND THE DUAL WHEEL SET TO SEPARATE FROM THE VEHICLE, RESULTING IN A CRASH WITHOUT PRIOR WARNING.

Remedy
DEALERS WILL INSPECT THE AXILOK NUTS FOR LOCKING CLIP ENGAGEMENT OR DAMAGE. THEY WILL BE ADJUSTED OR REPLACED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 800-547-0712.

Summary
ON CERTAIN TRUCKS BUILT WITH AXILOK REAR WHEEL SPINDLE NUTS, THE NUTS MAY HAVE BEEN IMPROPERLY INSTALLED, WITH ONE OR BOTH LOCKING CLIP TABS NOT PROPERLY ENGAGED OR DAMAGED.

Consequence
THIS MAY REDUCE THE NUT'S ABILITY TO RESIST ROTATION, POTENTIALLY ALLOWING THE NUT TO BACK OFF AND THE DUAL WHEEL SET TO SEPARATE FROM THE VEHICLE, RESULTING IN A CRASH WITHOUT PRIOR WARNING.

Remedy
DEALERS WILL INSPECT THE AXILOK NUTS FOR LOCKING CLIP ENGAGEMENT OR DAMAGE. THEY WILL BE ADJUSTED OR REPLACED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 800-547-0712.